FAS | Military | DOD 101 | Systems | Ships | Systems ||||
Index | Search | Join FAS

Mark 7 16-inch/50-caliber gun

The Mark 7 16-inch/50-caliber gun was the primary armament of the IOWA-class battleships. The IOWA class are the only battleships to mount this weapon which is a considerable improvement over the 16in/45cal guns mounted in the North Carolina and South Dakota classes. The Mark 7 gun fires two basic rounds, a 2,700 pound AP (Armor Piercing), which can penetrate up to 30 feet of concrete, and a 1,900 pound HC (High Capacity) shore bombardment projectile. The silk bags of propellant and the projectiles are elevatored to this room from the powder magazines and the shell decks below and then loaded into the gun in the gun room. To fire it, the gunner and his numerous mates complete a carefully choreographed sequence of events, first sliding the projectile into the breech, then gingerly placing the cylindrical silk bags of black powder, then ratcheting the breech shut. An ominous red stripe on the wall of the turret just inches from the railing marks the boundary of the gun's recoil.

On 19 April 1989 an explosion occurred in gun turret two aboard the USS Iowa. 47 crewmembers were killed when in one of the worst peacetime military accidents in US Naval history. The Department of the Navy, with the assistance of the FBI, conducted an investigation into the cause of the explosion. It concluded that Petty Officer Clayton Hartwig, a gunner's mate involved in the operation of the center gun, most probably intentionally caused the explosion in such a way that he hoped it would appear to be an accident. The Navy judge advocate general was in charge of the overall investigation. The Naval Investigative Service [NIS] was brought in four days after the blast, when most of the debris and other physical evidence had been cleaned up, to carry out what the Navy somewhat belatedly realized might be a criminal investigation rather than a search for an equipment malfunction. Despite that handicap, the Defense Department thought the NIS did a good job. A Pentagon inspector general oversight review of the NIS investigation, predicated on media allegations maligning NIS handling of the case, concluded that the NIS investigation was "thorough, complete, and expeditious. All logical investigative leads were covered, including those that required examining the backgrounds of persons closest to the explosion."

Subsequent investigations found that there was absolutely no proof that S1c. Clayton Hartwig committed that terrible crime. The General Accounting Office [GAO] assessed the Navy's investigation and conclusions, and Sandia National Laboratories in Albuquerque NM assisted the General Accounting Office by undertaking an independent technical analysis of the Navy's gun tests. On May 25, 1990, GAO and Sandia officials testified that the Navy's investigation suffered from significant shortcomings. In particular, Sandia's gun tests, and an initial follow-up test by the Navy itself, demonstrated that the Iowa explosion may have been caused by unsafe powder bags and an `over ram' of the bags during the firing of the 16-inch gun. This finding essentially eviscerated the Navy's conclusion that the explosion resulted from a wrongful intentional act. The testimony by the General Accounting Office also documented serious deficiencies in the Navy's employment of the battleships, both in terms of officer and enlisted manning and in terms of the training given to the gun crews.

During Operation DESERT STORM battleships USS WISCONSIN and USS MISSOURI fired more than 1.000 rounds of 16" ammunition in support of ground operations. USS MISSOURI alone fired more than one million pounds of ordnance. Using Remotely Piloted Vehicles and Marine spotters ashore, targets included artillery, mortar and missile positions, ammunition storage facilities and a Silkworm missile site. USS WISCONSIN's RPVs provided on-site reconnaissance support from 11 nautical miles out for advancing Marines. On 03 February 1991 the battleship USS MISSOURI (BB-63) fired eight 1.25-ton shells from its 16-inch guns at prefabricated concrete command and control bunkers Iraq was moving into Kuwait, destroying the bunkers. The barrage, totalling 18,000 pounds of high explosives, marked the first combat firing of the MISSOURI's 16-inch guns since the Korean War, and was in support of Marines and coalition ground forces. This also marked the first use of a Remotely Piloted Vehicle (RPV) for gun fire spotting in a hostile environment. And on 03 February USS MISSOURI destroyed an Iraqi artillery emplacement. On 06 February USS MISSOURI destroyed 4 artillery emplacements and a command bunker with another 16-inch gun barrage in support of Marines. In a second salvo, the MISSOURI fired 28 16-inch rounds against a radar control site complex, completely destroying it. 5-inch batteries also engaged. MISSOURI had fired a total of 112 16-inch shells and 12 five-inch rounds in 8 fire support missions over 48 hours.

Within two hours of relieving its sister battleship, USS WISCONSIN (BB 64) conducted its first naval gunffre support mission since the Korean War, firing an 11-round salvo with its 16-inch guns and destroying an Iraqi artillery battery in southern Kuwait. Secondary explosions reported. USS NICHOLAS escorted the battleship. USMC OV-10 called in the fire mission. On 07 February USS WISCONSIN pounded Iraqi artillery, electronic warfare and naval sites with its 16 inch guns. 50 rounds sunk or severely damaged 15 boats, destroyed piers at Khawr al-Mufattah Marina. 19 rounds also fired at artillery and missile sites. On 08 February USS WISCONSIN attacked a dozen Iraqi artillery emplacements with 36 rounds of its 16-inch guns in support of a Marine reconnaissance probe into occupied Kuwait. Using its remotely pilot vehicle to visually relay pictures and gun-firing coordinates of targets, the battleships's harassment and interdiction mission was designed to pin down and confuse Iraqi gunners during the Marine attack. Off Khafji, Saudi Arabia, WISCONSIN also blasted bunkers, troops and artillery sites, and continued its naval gunfire missions responding to calls for fire from U.S. and coalition forces on 09 February. Then on 12 February USS MISSOURI, USMC aircraft/artillery, and Saudi artillery mounted a combined arms attack on multiple fixed-position targets (Iraqi troops, artillery, a hardened command bunker and tanks) in southern Kuwait. The battleship expended 60 rounds in 9 naval gunfire support missions. On 21 February USS WISCONSIN destroyed a command complex, firing 50 rounds from off Khafji. RPVs spotted targets and provided coastline reconnaissance. Two days later USS MISSOURI destroyed targets on Favlaka Island off the coast of Kuwait City. On 24 February CINCCENTCOM announced the initiation of the ground offensive, and USS MISSOURI and USS WISCONSIN fired at targets in occupied Kuwait in support of the ground offensive. The next day USS WISCONSIN and USS MISSOURI continued naval gunfire support, with MISSOURI alone firing 133 rounds or 125 tons of ordnance on targets.

Naval Sea Systems Command's Indian Head Division of the Naval Surface Warfare Center is the Navy Design Agent (DA) for large caliber naval gun propellant and propelling charges, responsible for maintaining the designs for Navy gun propelling charges, controlling the design of the individual components of the propelling charges including the ignition systems, propellants, cartridge cases, and closure components.

Aboard the battleship USS IOWA (BB-61)

Crewmen work to move 16-inch projectiles brought aboard from a barge.

A view of several 1,900-pound high capacity (HC) projectiles in a handling room beneath one of the turrets. The blue projectiles in the background are 2,700-pound dummy projectiles.

A view of several 1,900-pound high capacity (HC) projectiles in a handling room beneath one of the turrets. The blue projectiles in the background are 2,700-pound dummy projectiles.

A petty officer tends a line as a 2,700-pound dummy projectile is drawn across the deck onto the rotating projectile ring in a handling room beneath one of the turrets.

As seen from above, a 2,700-pound dummy projectile travels up a hoist from a handling room.

As seen from abovve, a 2,700-pound dummy projectile travels up a hoist from a handling room.

A 1,900-pound high capacity (HC) projectile is hoisted up to the spanning tray.

Members of the gun crew place powder bags on the spanning tray.

The gun captain gives the signal to ram the powder bags on the spanning tray into the gun`s chamber.

A view of the breech end of the center gun inside the No. 2 turret.

A view of the closed breech.

A crewman releases the plug on the muzzle of the gun.

Sources and Resources

FAS | Military | DOD 101 | Systems | Ships | Systems ||||
Index | Search | Join FAS

Maintained by Robert Sherman
Originally created by John Pike
Updated Saturday, December 12, 1998 7:17:49 AM